Factory Price Gas Fired 10 Ton Steam Boilers

Factory Price Gas Fired 10 Ton Steam Boilers

Fuel gas control step and the blowing process air volume of the total fuel gas factory price fired 10 ton steam boilers steam boiler is achieved by adjusting a liquid coupling scoop blower. Organization fuel gas steam boiler combustion, is to make a, air pressure, air flow of secondary air with the good. Adjusting the amount of primary air should meet it carries the fuel into the furnace ignition of volatile oxygen required, and to maintain a certain speed, and without clogging the fuel discharge pipe of the jet having a certain rigidity. Primary air volume is too large and too small, the wind speed is too high and too low, should be avoided. In addition to adjusting the secondary air of combustion of the fuel should ensure that the oxygen demand, but must maintain a certain wind speed and primary air is mixed with the master time should have a strong stirring and mixing coke penetrate "the Gray" kinetic , which requires the case may be, each layer of the secondary air flow rate, in order to achieve stable combustion and flue gas excess oxygen appropriate destination. Fuel gas steam boiler, secondary air with what is better? Primary air volume air volume of the total share is called the primary air rate. A small air fraction, pulverized coal is heated to at least the heat required for the ignition point, fire faster, but the amount of primary air to satisfy the principle of combustion of volatiles. Secondary air mixed with the primary air time to the right. If it is mixed before ignition, means an increase in the amount of primary air, so that the ignition delay; hypoxia combustion secondary air if mixed will make late after ignition; if secondary air is mixed all at one position, since the secondary air temperature well below flame temperature, the flame temperature decreases, the combustion slows down, causing the fire. Therefore, the secondary air mixed with fuel should be based on the nature of the combustion zone as required timely sent, so that the combustion of oxygen, and will not reduce the flame temperature to ensure complete combustion and ignition stability. One or two wind speed with what is better? Fuel gas steam boiler once the wind speed is high, the fuel gas stream will catch fire in places far away from the burner, the ignition point postponed; once the wind speed is too low, it will cause a blocked ducts, and ignition point is too far forward, the burner will burn , but also easy to coke near the burner.

At 10:00 on September 6 and more, Harbin, a business is the purchase of a new boiler equipment installation, commissioning process when staff at a boiler pressure gauge index found that the performance of the boiler abnormal, but not so the commissioning personnel when the next step, a sudden loud noise, boiler explosion, a huge flame and furnace pressure debugging of oil spray everywhere, four commissioning personnel are subject to varying degrees of injuries, was taken to hospital for treatment .

Boiler is an energy conversion device, by entering the fuel to the boiler, chemical energy, power, etc., outputs a constant steam heat, hot water or organic heat carrier, to provide support for the heat industries. Meanwhile, the boiler is also a special equipment has a certain risk, when the boiler installation, commissioning, operation, etc., be sure to boiler operation safety first.

Now, Xiao Bian to operational safety considerations gas boiler summarize, we can refer to.

First, start, boost, steam supply

1, before the start of the preparatory work

Internal and external check: Check boiler, burner, a good state of the accessory device; action safety accessories, each of the valves, such as flexible instruments, the correct position.

Check the line voltage to meet the requirements, a variety of normal switch position, respectively, various auxiliary pump starts operating, the burner fan, oil pump is normal.

Boiler Feed: exhaust valve opening, to ensure the normal water level (just below the water level).

2, start

Firstly purging the furnace, induced draft fan suction time is usually about 10 minutes to ensure that no residual gas in the furnace, passing substitutions, and ignition for combustion air supply.

After firing is completed according to the adjustment amount of load required for combustion, the boiler into normal operation.

During startup, to closely monitor changes in water level, water boiler accident or occurrence textile full of water accidents.

Second, the normal operation

1, the water level

Fuel gas-fired boiler water table should be the red line indicating the high, medium and low water level, the operation shall not exceed the maximum safe level or below the minimum safe level.

Rinse water table at least once per shift, when there is suspicion of running water, rinse should always check.

2, steam pressure

Red lines indicate the working pressure gauge should have, so sensitive and reliable, the trap should be flushed at least once a week.

3, safety valve

Safety valve should seal intact, no leakage; once a week manually (or automatically) emission test, and begin start pressure, opening pressure, reseating pressure and test time, participants, etc credited maintenance log book u, for future reference .

4, sewage

Proceed as boiler water quality requirements of water quality testing personnel under the guidance of class 1 or 2 times sewage, sewage incident not too long, generally no more than 10 minutes.

Sewage should (preferably when shutdown), should be closely monitored sewage water level changes, and pay attention to safety at the time of low load, low pressure, high water level.

Many boilers when sharing a sewage mains, while sewage is prohibited.

Third, shutdown

1, the normal shutdown

After normal boiler shutdown should generally be reduced boiler load operation, press the boiler shutdown procedure. Actuated pump water to high water level, pressure steam boiler to be dropped after 0.3MPa flushing water table and sewerage operations, and finally close the raft, cut off the power supply control cabinet, wipe equipment, clean up the environment and health, For water, the water temperature should be below after 70 ℃, before proceeding.

2, emergency shutdown

When the boiler operation in the following situations should immediately shutdown:

Furnace water level drops below the minimum water level gauge visible edges.

Increasing water supply and other measures, but digital still continue to fall.

Boiler water level exceeds the highest visible water table level (full of water), the water still can not see the water level.

All water supply system water pump failure or malfunction, not water to the boiler.

Water gauge or safety valve all the failures.

Endanger the boiler element is damaged and the safety of operating personnel.

Combustion equipment damage, or furnace wall collapse and other red-hot boiler structure is a serious threat to the safe operation of the boiler.

Other anomalies endanger the safe operation of the boiler.

3, maintenance

Before maintenance work should be well prepared, as before entering the drum interior work, must be of sufficient strength to connect all of the metal blocking plate spaced reliable steam, water, sewage and other operation of the boiler pipes, and the drum manholes and hand holes (boiler shell) is opened, so that air convection period.

After the completion of preparations to repair. Should ensure that the quarterly frequency of boiler maintenance and repair of the year.

Advances in technology to the boiler industry into new and innovative ideas, now the boiler manufacturers boiler are easy targets toward the operation forward, but in the use of the boiler, improper operation or other quality problems still exist, these failures will It is causing the direct cause of the explosion boilers. Therefore, when using the boiler must be in strict accordance with safety practices boiler, security incidents strangled in the cradle.

Different natural gas factory price fired 10 ton steam boilers energy-saving measures as well as gas-fired boiler with environmental issues become more critical, more and more people are concerned about the importance of the environment for our development. Today, gas steam boilers in industrial production is very common, how to reduce the energy consumption of gas steam boilers, which we have been explored. We can take the following measures in natural gas steam boiler operation for energy. 1, the amount of steam needed for industrial production of a reasonable choice, and the number of the rated power station boiler steam boiler gas, in both cases the higher the degree of matching with the actual exhaust gas loss is smaller, the obvious energy saving. 2, the fuel in contact with air: fuel amount so that an appropriate amount of air and the optimum composition ratio of combustion, this would both improve fuel combustion efficiency and reducing emissions of polluting gases, energy to achieve the dual goals. 3, reducing the temperature of the exhaust gas steam boiler: the temperature of the boiler flue gas to reduce the effective use of exhaust heat generated in general, the efficiency of the boiler used is 85-88%, the exhaust gas temperature is 220-230 ℃. If the setting of energy-using the exhaust heat or the like, the exhaust gas temperature falls to 140-150 deg.] C, the boiler efficiency can be increased to 90-93%. 4, recycle heat from the boiler blowdown water: water using continuous blowdown heat by heat exchange, in addition to improving water temperature itching water to achieve energy saving gas steam boiler. At the same time, measures energy-saving gas steam boiler can also be reasonably recovered condensate heating system, and the heat of the condensate water recycling. It is different from the gas boiler and gas boiler: 1. Gas circulating fluidized bed combustion boiler coal by crushing device by the belt into the coal bin, by using multicast coal stoker wind, thrown into the furnace; circulating ash by heating, fluidized combustion process. After coal to gas and coke oven gas and purge gas mixed together by the four burners directly injected into the combustor. 2. Combustion of Coal is mainly composed of water and ash content and the elements C, H, O, N, S etc., the heat released by combustion of coal to produce SO2, SO3, NOx ash and moisture, and SO2, SO3, NOx discharged from the flue gas the atmosphere, pollute the environment, cause harm to humans. And the main component of coke oven gas and purge gas are CO and H2, after combustion, produce mainly CO2 and H2O, SO2 emissions relative gas boiler gas boiler, SO3, NOx is much less. 3. Usually ventilation negative pressure combustion gas boiler, the combustion process is to group together to complete the mating with the mating blower and induced draft fan, the coal combustion process, requires a lot of air and the furnace wall due to the leakage of the flue, the excess air coefficient of up to between 2.1-2.5. Gas boiler combustion slightly positive or slightly negative pressure, a small amount of wind required, air is preferably premixed with the gas within the combustor. No leakage factor positive pressure combustion flue and the furnace wall, the flue outlet air ratio operation may 1.05-1.2.4. Fuel explosive gas boiler combustion safety, the furnace explosion hazard unlikely to occur. The gas-fired boiler in the explosive concentration limits encountered fire will explode. More dangerous. 5. Gas boiler control difficult due to coal boiler, material thickness, amount of the blowing, the amount of the wind, the wind mixture ratio of coal and other reasons, to be automatically adjusted according to the operating parameters of the boiler load is large. Less impact on the factors of the gas boiler, the burner may be adjusted according to the size of the load valve, easy to achieve automatic control.

Gas-fired factory price fired 10 ton steam boilers and gas steam boiler at any time there is any good compared to the country more and more attention to environmental protection, gas steam boiler has been a great blow, and relatively gas steam boiler by many users of all ages, in recent years, the country also strongly promote the use of gas-fired boiler, gas steam boiler then compared with the gas steam boiler what good is it? And today we work together to explore. Gas-fired steam boiler steam boiler and gas each accounted for half of the market, showing potential rival, but in the long run, gas steam boiler will obviously be the only dominant market. Do not believe, look! 1. Purchase costs: gas boiler is evident in the technical and auxiliary facilities are far ahead of the gas boiler, and it is equipped with a special gas burner. 1 steam boiler tonnage, for example, the price of gas than the gas boiler boiler on high about 30%. 2. Construction costs: The costs mainly from the boiler room. Because the corresponding auxiliary equipment more gas steam boiler, the boiler room in the building have a little more money. The gas boiler auxiliary facilities require little or automatic control and operation, and automatic alarm and automatic protection, not only save building costs, but also safe and reliable; Also connected to the gas pipeline, the burner will automatically supply gas can effectively save costs staff. The gas-fired boilers because of the need of coal on the program, so it needs some staff payroll. 3. Fuel cost: around this by looking at the actual specific fuel price can be clearly seen. The fact is that the amount of gas than the gas burned per hour for much more. 4. environmental costs: in the need to protect the environment, review the current gas boiler more strict. The gas steam boiler due to the operation of the economy, environmental protection and energy saving, as well as government policy to encourage more and more widely used.

Factory Price Gas Fired 10 Ton Steam Boilers Related Information

factory selling 4 ton 2 ton coal fired steam boiler

China Gas Boiler manufacturer, Steam Boiler, Coal China Gas Boiler supplier, Steam Boiler, Coal Boiler Manufacturers/ Suppliers - Henan Yuanda Boiler Corporation Ltd. Factory Price 1 Ton 2 Ton 3 Ton 4 Ton 5 Ton 6 Ton 8 Ton 10 Ton 15ton 20 Ton Steam Boiler FOB Price: US $35,000 / Set China Best Selling Gas and Oil Fired Steam Boiler FOB Price: US $1,000-500,000 / Piece

Get a Quote

2Ton Boiler Factory Price -

1 Ton Steam Boiler, 5 Ton Steam Boiler, 10 Ton Steam Boiler manufacturer / supplier in China, offering Factory Price 1 Ton 2 Ton 3 Ton 4 Ton 5 Ton 6 Ton 8 Ton 10 Ton 15ton 20 Ton Steam Boiler, Steam Boiler Capacitiy 10 Ton Per Hour Boiler Pressure 200psig, Chinese Industrial Coal Fired Steam Boilers for Sale in Pakistan and so on.

Get a Quote

2Ton Boiler Factory Price -

1 Ton Steam Boiler, 5 Ton Steam Boiler, 10 Ton Steam Boiler manufacturer / supplier in China, offering Factory Price 1 Ton 2 Ton 3 Ton 4 Ton 5 Ton 6 Ton 8 Ton 10 Ton 15ton 20 Ton Steam Boiler, Steam Boiler Capacitiy 10 Ton Per Hour Boiler Pressure 200psig, Chinese Industrial Coal Fired Steam Boilers for Sale in Pakistan and so on.

Get a Quote

2Ton Boiler Factory Price - dorfwirt-hagendorf.de

Malaysian oil fired boilers prices - zorginharen.nl. China 2ton Natural Gas Boiler for Paper Making . Industrial Steam Boiler, Industrial Boiler Price, Gas Boiler manufacturer / supplier in China, offering 2ton Natural Gas Boiler for Paper Making Factory, 3 Pass Stainless Steel Smoke Tube Diesel Fired Steam Boiler, Quickly Installed Low Pressure Gas Oil Steam Boiler and so on.

Get a Quote

Commercial Gas Fired Steam Boiler Factory Price

10 Ton Coal fired boiler Steam Boiler Factory Price. Except hot oil boiler, oil gas fired steam boiler and biomass water tube steam boiler is for example: WNS series natural gas fired boiler, YY(Q)W oil gas fired thermal oil heater-Free Chat

Get a Quote

gas fired 10 ton steam boiler - dm-psp-tubes.be

10 steam tons of gas boiler price -Large heating boil. 1.25MPA and 10 Tons Boiler Price-- 2019-4-26 · 10 ton boiler can be divided into gas fired boiler, oil fired boiler, coal fired boiler, biomass boiler and so on.

Get a Quote

2Ton Boiler Factory Price -

1 Ton Steam Boiler, 5 Ton Steam Boiler, 10 Ton Steam Boiler manufacturer / supplier in China, offering Factory Price 1 Ton 2 Ton 3 Ton 4 Ton 5 Ton 6 Ton 8 Ton 10 Ton 15ton 20 Ton Steam Boiler, Steam Boiler Capacitiy 10 Ton Per Hour Boiler Pressure 200psig, Chinese Industrial Coal Fired Steam Boilers for Sale in Pakistan and so on.

Get a Quote

15 ton steam boiler agent in paper factory

10 ton boiler price for food facto. 10 ton steam boiler for food factory. 25 ton coal boiler for food factory. Coal fired hot water boiler 10 ton food factory steam boiler 5t-130t waste heat boiler manufacturer 2 tons steam boiler model Advantages of oil and gas boilers Industry 15 ton horizontal steam boiler for paper 10 ton paper factory .

Get a Quote

Industrial Boiler Catalogue

2016-8-15 · Industrial Boiler Catalogue. Search. Search. Home; 2 ton gas and oil fired steam boilers price 3 ton Full Automatic Gas Fired Steam Boiler For Hotels 6 ton Gas And Oil Fired Steam Boilers in Alcohol Factory 6 ton gas boiler in Pakistan 8 ton steam boiler in beer industry 15 ton gas oil steam boiler in china 20 ton Natural Gas Steam Boiler

Get a Quote

10 Ton Rubber Industrial Steam Boilers, Diesel Fired

10 Ton Rubber Industrial Steam Boilers, Diesel Fired Steam Boiler Low Pressure . Brief Introduction . 1. The WNS oil/gas fired steam boiler is a horizontal internal combustion and

Get a Quote

factory selling 4 ton 2 ton coal fired steam boiler

China Gas Boiler manufacturer, Steam Boiler, Coal China Gas Boiler supplier, Steam Boiler, Coal Boiler Manufacturers/ Suppliers - Henan Yuanda Boiler Corporation Ltd. Factory Price 1 Ton 2 Ton 3 Ton 4 Ton 5 Ton 6 Ton 8 Ton 10 Ton 15ton 20 Ton Steam Boiler FOB Price: US $35,000 / Set China Best Selling Gas and Oil Fired Steam Boiler FOB Price: US $1,000-500,000 / Piece

Get a Quote

boiler factory, boiler factory Suppliers and

Boiler Factory Taiguo Brand Steam Boiler Factory Price Energy Saving Biomass Pellet Fired Boiler. china factory small steam boilers home electric heating water wall hung electric electric boiler for ukraine IB0324 Customization Design Fire Tube Garment Factory 2 ton/hour Gas - Fired Fuel Steam Boiler.

Get a Quote

natural gas fired 10 ton boiler

60 ton natural gas fired power plant boiler Nepal. 20 Ton Biomass Fired Steam Boiler Price - 20 ton biomass steam boilers for sale in Philippine . 20t biomass steam boilers for sale in Philippine aims to improve the efficiency of boiler, focusing mainly on minimizing the loss of useful heat to the surrounding from the hot flue gas and walls of the boiler. biomass fired steam boiler is designed

Get a Quote

gas steam boiler factory - ferienwohnung-rohlfs.de

Boiler, Steam Boiler, Gas Boiler manufacturer / supplier in China, offering Industrial 10 Ton Hr Oil Gas Fired Boiler for Textile Factory, Wns Model Oil Gas Fired Hydrogen Boiler for Heating, 10tons/H Gas Fired Boilers Corrugated Furnace with Condenser and so on. Get a quote

Get a Quote

10 Ton Rubber Industrial Steam Boilers, Diesel Fired

10 Ton Rubber Industrial Steam Boilers, Diesel Fired Steam Boiler Low Pressure . Brief Introduction . 1. The WNS oil/gas fired steam boiler is a horizontal internal combustion and

Get a Quote

Do You Want To Get An Exclusive Project Plan ?

7 * 24 * 365 endless service, click the button to provide you with professional and fast solutions at any time

Scroll to Top